TANCHITO'S RESTAURANT

Janitorial sink is in disrepair. [CA] Repair plumbing fixture and maintain in clean and good repair.

Opening under back door larger than 1/4" . FRP is deteriorating in kitchen. Some portions of the walls/ceilings show deterioration. [CA] Eliminate gap greater than 1/4" to prevent the entrance and harborage of vermin.

Bar/service area lacks hand wash sink. [CA] All food facilities shall provide an operable handwashing station in food preparation/ service areas.

Food handler cards are not available for all working employees [CA] Each food handler shall maintain a valid food handler card for the duration of his or her employment as food handler. A valid food handler card shall be provided within 30 days of after the date of hire.

Leak found at drainline (food preparation sink). Handles at janitorial sink are in disrepair. [CA] Repair plumbing fixture and maintain in clean and good repair.

Sanitizer concentration at 3 compartment warewash sink measured 0PPM.[CA] Manual warewashing shall be accomplished by using a three-compartment sink where the utensils are first precleaned, washed with hot soapy water, rinsed with hot water, sanitized with an approved method, and air dried. Use 1 TBS of bleach (5.25%) per 1 gal. of water for chlorine solution (100 PPM). Use 1 tbs of quaternary ammonium (10%) per 2 gal. of water for quaternary ammonium (200 PPM).

Deep container of beans found cooling at ambient temperature. [CA] After heating or hot holding, Potentially Hazardous Foods (PHFs) shall be cooled rapidly from 135°F to 70°F within 2 hours and from 70°F to 41°F within 4 hours. Approved cooling methods include: 1) Placing the food in shallow pans 2) Separating the food into thinner or smaller portions. 3) Using rapid cooling equipment (Ex. blast chiller) 4) Using containers that facilitate heat transfer (ex. stainless steel) 5) Adding ice as an ingredient. 6) Using ice paddles 7) Using an ice bath and stirring frequently 8) Accordance with a HACCP plan. Cooling foods shall have enough space around the containers for cold air to circulate, be loosely covered, or uncovered and stirred as frequently needed to evenly cool.

Lids at dumpsters found to be uncovered at time of inspection. [CA] Refuse containers shall be covered at all times when not in use.

Cooked beans held at food preparation table measured >41F,<135F. [CA] PHFs shall be held at 41°F or below or at 135°F or above. [COS] Per PIC cooked beans held at preparation table for less than 1 hr. PHF moved to refrigerator for rapid cooling.

Food preparation observed in middle sink of active 3 compartment warewash sink. [CA] Food preparation shall only occur in approved areas. Use available food preparation sink for food preparation .

Broken floor tiles found throughout the kitchen. [CA] Replace broken floor tiles with a smooth and of durable construction and nonabsorbent material that is easily cleanable.

Heavy builldup found on exhaust filters. Gaps in ventilation filters Yellowing of walls and ceiling outside of exhaust filters. [CA] Ventilation hood filters shall be maintained clean and good repair. Some bulbs in kitchen and food preparation areas are not shielded. [CA] Light bulbs shall be shielded, coated or otherwise shatter-resistant in areas where there is unpackaged foods, clean equipment, utensils, linens, or unwrapped single use articles.

Several wet/used wiping towels found on food preparation tables. [CA] Wiping towels shall be stored in sanitizing solution of an approved concentration when not in use (100 ppm - chlorine, 200 ppm - quaternary ammonium).

Openings larger than 1/4" found at walls in food preparation area and at rear door. [CA] Eliminate gap greater than 1/4" to prevent the entrance and harborage of vermin. Employee personal care items found stored on shelf with plates. [CA] Personal care items (medication/vitamins) shall bear a legible manufacturer's label and stored in a designated storage area for personal items.

Linen used to cover food.[CA] Linen shall not be used in contact with food unless they are used to line a container for the service of foods and are replaced each time the container is refilled for a new consumer and laundered prior to reuse.

Observed numerous missing floor tiles and missing grout in-between floor tiles in the kitchen. [CA] Replace broken floor tiles with a smooth and of durable construction and nonabsorbent material that is easily cleanable. Observed heavy accumulation of grease and grime on floors and walls in the kitchen as well as the preparation area by the area area: - Wall next to the cook line. - Wall above the steam table. - Floor and walls around the floor mixer by the bar area. [CA] Walls and/or floors in food preparation area shall be kept clean. Regularly clean under equipment to prevent accumulation of debris.

The only hand wash station in the kitchen lacked paper towels at the time. Hand wash station at the only available restroom lacked hand soap. [CA] Handwashing facilities shall be equipped with handwashing cleanser and single-use sanitary towels in dispensers. Hand soap and paper towels shall be easily accessible and readily available at all times. [COS] Owner refilled paper towel and hand soap dispensers.

Accumulation of grime observed on door handles of all refrigerators. Accumulation of grime and food residues observed on and inside food preparation refrigerators. [CA] Nonfood-contact surfaces of equipment shall be kept free of an accumulation of dust, dirt, food residue, and other debris.

Observed towels used as covers for various food items in the food preparation refrigerator and walk-in refrigerator. [CA] Linen shall not be used in contact with food unless they are used to line a container for the service of foods and are replaced each time the container is refilled for a new consumer and laundered prior to reuse.

Numerous live fruit flies observed in the bar area. [CA] Food facility shall be kept free of non-disease carrying insects, weevils, ants, gnats, and fruit flies.

Various types of pupusa fillings at the cook line maintained in inadequate ice bath. PHF items measured between 45F to 50F. [CA] PHFs shall be held at 41°F or below or at 135°F or above. [COS] Instructed owner to add ice to ice bath to maintain proper cold holding temperatures.

Owner stated that currently the plumbing for the janitorial sink is being repaired. Janitorial sink is not available for use. [CA] At least one curbed cleaning facility or janitorial sink equipped with hot and cold water and drain shall be provided. Liquid waste shall be disposed of through the approved plumbing system and shall discharge into the public sewerage or into an approved private sewage disposal system. [SA] Temporarily dispose of mop water down toilet until plumbing has been repaired.

The hot water faucet handle at the three compartment warewashing sink is non-functional (All other sinks within the facility have a functional hot water supply). [CA] Repair plumbing fixture and maintain in clean and good repair. Hot water shall be supplied at a minimum temperature of at least 120°F measured from the faucet throughout facility except at handwash sinks. [COS] The hot water faucet valve was replaced at the time of inspection. Hot water measured at a minimum of 120 F at the 3 compartment sink.

Sanitizing solution at the three-compartment sink measured at 25 PPM chlorine. [CA] Manual sanitization shall be accomplished in the final sanitizing rinse by contacting a chlorine solution of 100 PPM concentration for at least 30 seconds or by contacting a quaternary ammonium solution of 200 PPM concentration for at least 60 seconds. [COS] Owner added more chlorine bleach. Solution measured at 100 PPM.

Observed gaskets on food preparation refrigerator and walk-in freezer heavily torn and in disrepair. [CA] Replace rubber gaskets.

--48 HOUR NOTICE— Our records indicate this facility is operating without a valid permit and has a delinquent account. Your balance due is $ 1,975.00. Payment must be made immediately to DEH at the address at the top of this report or via our website at www.Ehinfo.org. A facility that submits payment of the outstanding balance within 48 hours (2 business days) of this notice will be issued and mailed an operating permit by this department. Failure to comply within 48 hours will result in facility closure and additional enforcement, including but not limited to reinspection(s) and additional cost recovery fees. A facility found to be in continued operation without a permit may incur a penalty of three (3) times the operating permit fee, and fee(s) for re-inspection(s) charged at the current hourly rate approved by the Santa Clara County Board of Supervisors. Penalties and fees incurred due to enforcement activities must be paid in full prior to the issuance of an operating permit. * Invoice provided to owner.

Heavy build up of grease observed on wall behind the food preparation table next to the griddle. Heavy accumulation of food residue observed on floor and wall around the floor mixer at the right side storage room. [CA] Walls and/or floors in food preparation area shall be kept clean. Regularly clean under equipment to prevent accumulation of debris. Observed FRP behind the three-compartment sink partially detached with large gap. [CA] Secure wall. Eliminate gap greater than 1/4" to prevent the entrance and harborage of vermin. Numerous missing floor tiles. [CA] Replace broken floor tiles with a smooth and of durable construction and nonabsorbent material that is easily cleanable.