KV NOODLE

1. Repeat Violation: Facility has several pieces of equipment that are not ANSI accredited. - 1x Midea Chest Freezer - 1x Maytag Upright Freezer - 1x no brand Vietnamese steamer that had a 3 prong plug attached several terminations via wire nuts - 1x non ANSI ice machine - 1x Panasonic microwave [CA] New and/or replacement food equipment shall be certified or classified for sanitation by an American National Standards Institute (ANSI) accredited certification program (e.g. NSF, UL EPH, UL Sanitation, CSA Sanitation, or ETL Sanitation). 2. Facility is using cardboard to line shelves throughout the facility. [CA] Discontinue the use of cardboard boxes to line shelves, use approved equipment made of materials that is easily cleanable, durable, smooth, and nonabsorbent.

The mop sink is draining slowly and has standing wastewater. no overflow or back up observed. [CA] The mop sink and all waste water drains shall be functioning properly. A follow up inspection will be conducted within 24 hours to verify correction.

Facility has added wallpaper to the bar area. Wall paper is not seamless and smooth. [CA] Walls shall be constructed to be made of durable, smooth, nonabsorbent, and easily cleanable surface materials.

1. Food items in bulk containers are not labeled. [CA] Working containers holding food or food ingredients that are removed from their original packages shall be identified with the common name of the food if not easily recognizable. 2. Bulk foods are not stored in approved containers. [CA] Store open bulk foods in approved NSF containers with tight fitting lids.

Rice was packaged into plastic bags and was found cooling stacked over one another in a plastic bin. [CA] Properly store cooling foods in such a way to allow proper air flow. [COS] Rice packages were moved to sheet trays in single layers to promote even and effective cooling. Rice had been cooling for ~45 minutes and measured at 110F.

Raw shrimp was found stored above cooked shrimp in the upright freezer. [CA] All food shall be separated and protected from cross-contamination. Store all raw meat or other raw products of animal origin below ready-to-eat food items.

A hatched ootheca was observed behind the non-ANSI upright freezer in the kitchen area. No other evidence of vermin observed. [CA] Clean and sanitize area of dead cockroaches.

1. The mop sink has a leak at the faucet. 2. The handwash sink at the cookline is draining slowly. [CA] Maintain plumbing in good repair.

Three 5 gallon containers of pho were measured between 52-57F. Per PIC, they finished cooking at midnight and were placed in the walk in cooler to cool down. [CA] After heating or hot holding, Potentially Hazardous Foods (PHFs) shall be cooled rapidly from 135°F to 70°F within 2 hours and from 70°F to 41°F within 4 hours. Approved cooling methods include: 1) Placing the food in shallow pans 2) Separating the food into thinner or smaller portions. 3) Using rapid cooling equipment (Ex. blast chiller) 4) Using containers that facilitate heat transfer (ex. stainless steel) 5) Adding ice as an ingredient. 6) Using ice paddles 7) Using an ice bath and stirring frequently 8) Accordance with a HACCP plan. Cooling foods shall have enough space around the containers for cold air to circulate, be loosely covered, or uncovered and stirred as frequently needed to evenly cool. [COS] Items were discarded. See VC&D report.

Facility has several pieces of equipment that are not ANSI accredited. - 1x Midea Chest Freezer - 1x Maytag Upright Freezer - 1x juicer - 2x no brand toaster oven - 1x Panasonic microwave [CA] New and/or replacement food equipment shall be certified or classified for sanitation by an American National Standards Institute (ANSI) accredited certification program (e.g. NSF, UL EPH, UL Sanitation, CSA Sanitation, or ETL Sanitation).

The outdoor enclosed refuse space is not maintained clean. The dumpster is stored outside of the enclosure and is overflowing with refuse. [CA] Refuse containers shall be collected or cleaned frequently enough to minimize the development of objectionable odors or conditions that attract or harbor insects or rodents. Outside refuse enclosure shall be kept clean and free of debris. Failure to comply may result in further enforcement actions from this department.

Flies were present in the facility. [CA] Ensure to maintain the facility free of animals, pests, and vermin.

1. Staff were observed rinsing a wok and spoon in the prep sink and return to the cook line. [CA] Manual sanitization shall be accomplished in the final sanitizing rinse by contacting a chlorine solution of 100 PPM concentration for at least 30 seconds or by contacting a quaternary ammonium solution of 200 PPM concentration for at least 60 seconds. [COS] Staff were instructed to wash, rinse, and sanitize the items. Items were sanitized in the undercounter dishwasher. 2. The deli slicer had an accumulation of food debris in the blade and other food contact areas. [CA] Meat slicer shall be washed, rinsed and sanitized every 4 hours or less after initial use.

1. Repeat Violation: Shrimp was found thawing in still water. 2. Shrimp were found thawing in the boxes in the first basin of the three compartment sink. [CA] Frozen potentially hazardous food shall only be thawed in one of the following ways: 1) under refrigeration that maintains the food temperature at 41°F or below, 2) completely submerged under potable running water for a period not to exceed two hours at a water temperature of 70°F or below, and with sufficient water velocity to agitate and flush off loose particles into the sink drain, 3) in a microwave oven if immediately followed by immediate preparation, 4) as part of a cooking process. [COS] 1. Shrimp were moved to the prep sink under cold running water. [COS] 2. Items were moved to the walk in cooler to thaw

Facility is using bowls and containers as scoops for dry bulk items (rice and sugar). [CA] Use approved utensils such as scoops or spoons with handles to ensure hands do not come in direct contact with food.

The Environmental Health Permit is not posted. [CA] The health permit issued by this department shall be posted in a conspicuous place in the food facility.

1. No Food Safety Certificate was available. [CA] Food facilities that prepare, handle, or serve non-prepackaged potentially hazard foods shall have a valid Food Safety Certificate available for review at all times. 2. Food handler cards for staff were unavailable. Only one food handler card was present. [CA] Each food handler shall maintain a valid food handler card for the duration of his or her employment as food handler. A valid food handler card shall be provided within 30 days of after the date of hire.

1. In the kitchen area, on the prep cooler cutting board, a tub of preportioned rice measured between 56-60F. Per staff it had been out for about an hour. 2. In the kitchen area, on the prep table, two bags of rice noodles that state "perishable, keep refrigerated" were measured at 90F at around 2:30 pm. Per staff, they were delivered at around 9 am. 3. In the kitchen area, at the right prep cooler, beef was stored over the fill line and measured above 55F. Per staff, it had been there since yesterday. [CA] PHFs shall be held at 41°F or below or at 135°F or above. Ensure to properly store items and use equipment as intended. [COS] 1. Item was moved to the walk in cooler. [COS] 2. Items were discarded. [COS] 3. Items were discarded.

Raw beef and raw shelled eggs were found stored above produce in the walk in cooler. [CA] All food shall be separated and protected from cross-contamination. Store all raw meat or other raw products of animal origin below ready-to-eat food items.

Facility has several bulk items open in the dry storage area. [CA] Store open bulk foods in approved NSF containers with tight fitting lids.

In the kitchen a fly was observed adulterate a bus tub of eggroll filling. [CA] Food is adulterated if it bears or contains any poisonous or deleterious substance that may render it impure or injurious to health and shall be discarded immediately. Ensure to maintain the facility free of animals, pests, and vermin. [COS] Item was discarded.

Repeat Violation: Facility lacks the testing materials for their choice of sanitizer, chlorine. [CA] Testing equipment and materials shall be provided to adequately measure the applicable sanitization method used during manual or mechanical warewashing.

In the kitchen area, at the only handwash sink, the soap dispenser was not working. [CA] Provide handwashing cleanser in dispenser at handwash stations at all times. [COS] Staff readjusted the automatic dispenser and it began working again.

Facility lacks a probe type thermometer. [CA] An accurate easily readable metal probe thermometer (accurate to +/- 2°F) that is designed to measure the temperature of thin masses shall be provided and readily available to accurately measure the temperatures of potentially hazardous foods.

The floors under the three refrigeration equipment near the dining area has ana accumulation of food debris and grime. [CA] Ensure to maintain the floors, walls, and ceilings of the facility clean and in good repair.

An open bottle of medication and a different closed bottle were found stored on top of the ice machine. [CA] Store chemicals separate and away from the storage and preparation of food or food contact surfaces and linens.

1. Interior floors of the upright freezers have an accumulation of food debris. 2. Lids of bulk food storage containers have an accumulation of food debris and grime. [CA] Nonfood-contact surfaces of equipment shall be kept free of an accumulation of dust, dirt, food residue, and other debris.

The outdoor enclosed refuse space is not maintained clean. The dumpster is stored outside of the enclosure and is overflowing with refuse. [CA] Refuse containers shall be collected or cleaned frequently enough to minimize the development of objectionable odors or conditions that attract or harbor insects or rodents. Outside refuse enclosure shall be kept clean and free of debris. Failure to comply may result in further enforcement actions from this department.

The front door and two back doors were propped open. [CA] Keep the doors closed at all times to prevent the entrance and harborage of vermin.

Live nymphs were observed on the floor under the prep coolers, on the wall above the walk in cooler, and on the large chest freezer. A dying adult cockroach was observed falling into the upright cooler when the door was opened. Several dead cockroaches were found throughout the facility. [CA] The premises of each food facility shall be kept free of vermin. A food facility shall not operate when there is a vermin infestation that has resulted in the contamination of food contact surfaces, food packaging, utensils, food equipment, or adulteration of food(s). The food facility shall cease operation of the food facility immediately. The food facility shall remain closed until: there is no longer evidence of a vermin infestation; all contaminated surfaces have been cleaned and sanitized; and contributing factors such as cleaning, repairs, and the elimination of harborages have been resolved. Contact District Specialist at (408) 418-2726

Facility lacks the testing materials for their choice of sanitizer, chlorine. [CA] Testing equipment and materials shall be provided to adequately measure the applicable sanitization method used during manual or mechanical warewashing.

In the kitchen area, on the prep cart across the cook line, a dead cockroach body was observed at the bottom of a container of cooking oil. [CA] Food is adulterated if it bears or contains any poisonous or deleterious substance that may render it impure or injurious to health and shall be discarded immediately. [COS] The oil was discarded. See VC&D report.

Chlorine at the dishwasher measured at 0 PPM while no active ware washing was taking place. [CA] Maintain chlorine in mechanical warewash machine at 50 PPM. [COS] PIC was able to fix the machine at time of the inspection. Chlorine measured at 50 PPM.

Facility offers raw or undercooked animal products on their menu with no consumer advisory or disclosure. [CA] Provide consumer warning for the sale of raw or undercooked animal-derived foods.

In the kitchen area, at the only hand sink, the hot water did not work. [CA] Handwashing facilities shall be equipped to provide minimum 100°F water under pressure for a minimum of 15 seconds.

REPEAT VIOLATION: 1. Upon entering the facility several dead cockroaches of all life stages were observed on the floor near the ice machine and swing door. 2. In the kitchen area, at the cook line, live and dead cockroaches were observed on the floor and on cooking equipment. 3. Live cockroaches were observed on the wall above the walk in cooler. 4. Dead cockroaches were observed inside the upright cooler. [CA] The premises of each food facility shall be kept free of vermin. A food facility shall not operate when there is a vermin infestation that has resulted in the contamination of food contact surfaces, food packaging, utensils, food equipment, or adulteration of food(s). The food facility shall cease operation of the food facility immediately. The food facility shall remain closed until: there is no longer evidence of a vermin infestation; all contaminated surfaces have been cleaned and sanitized; and contributing factors such as cleaning, repairs, and the elimination of harborages have been resolved. Contact District Specialist at (408) 418-2726

Facility has a non ANSI accredited microwave. [CA] New and/or replacement food equipment shall be certified or classified for sanitation by an American National Standards Institute (ANSI) accredited certification program (e.g. NSF, UL EPH, UL Sanitation, CSA Sanitation, or ETL Sanitation).

REPEAT VIOLATION: Household can of spray insecticide was observed near the hand sink in the kitchen. [CA] Only those insecticides, rodenticides, and other pesticides that are necessary and specifically approved for use in a food facility may be used.

REPEAT VIOLATION: The back door is kept open and the screen door does not stay closed. [CA] Keep back door closed at all times to prevent the entrance and harborage of vermin.

Shrimp was found thawing in still water. [CA] Frozen potentially hazardous food shall only be thawed in one of the following ways: 1) under refrigeration that maintains the food temperature at 41°F or below, 2) completely submerged under potable running water for a period not to exceed two hours at a water temperature of 70°F or below, and with sufficient water velocity to agitate and flush off loose particles into the sink drain, 3) in a microwave oven if immediately followed by immediate preparation, 4) as part of a cooking process.